 |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
 |
 |
 |
||||||||||||||||||
| 310-374-8047 |  |
 |
 |
 |
 |
|
 |
 |
 |
 |
 |
 |
 |
 |
 |
 |
 |
 |
|
|
 |
 |
 |
 |
 |
 |
 |
|
|||||||||||||
|
||||||||||||||||||||
|
|||||||||||||||||||||||||||||||||||||||||||||||||||||||||||||||||||||||
|
||||
The Bubba rope is representative of the higher end manufactures in that they have a tag attached on one end of the rope with all the specs. This is important – don’t use anything for recovery if you do not know the ratings for which it is designed. If you buy any recovery gear that does not have a tag, write, carve or engrave the information from the package onto the product. The Bubba rope is the brand name for a class of ropes referred to as KERR – kinetic energy recovery rope. Kinetic energy recovery ropes have been around for a long time. I made my own version back in the 70’s and am a firm believer in using them. War StoryOne rainy fall day in southern Michigan, I wanted to go wheeling but had no one to back me up. I drove my 70 CJ5 out to a local spot and waited for someone else to show up. It was a short wait. Another vehicle agreed to go with me. It was fun - just enough mud on mostly flat ground to be challenging. About an hour into it, we rounded a thicket of trees to find 3 full size pickups buried in the mud. My observation was that one vehicle was going too fast and could not make a required turn and ended up in the swap. How the other vehicles got stuck I don’t know but it was obvious that his buddy hooked up to him with a chain and tried to tug him out. The result was he spun his wheels until he was buried to his axles.So this reminds me of a couple more rules (besides don't go alone): 1) Never use chain in a “dynamic” recovery. Something or someone is sure to be damaged. 2) On soft and wet stuff always start with a “snatch” not a tug. And if the other vehicle does not move with you when you hit the end of the rope get off the power immediately. Using my homemade version of a Bubba rope, I was able to pull all 3 pickups out even though they out weighted my vehicle by 2 to 3 times. Not only did they weigh more, they were stuck in mud. As a rule of thumb you can assume you will need to pull up to 70% of the GVW of the stuck vehicle if they are stuck to the bottom of the rims in mud (we call that “shallowly” stuck) and 100% of the GVW if they are grounded on their axles. BTW, just as I left, I watched the first vehicle try to negotiate that turn in the same manner as he had the first time - too fast. I left him stuck in the swap right where I pulled him out. Maybe his buddies pulled him out.
So why do most people only carry a flat strap?My opinion is cost and space. A KERR can be as much as 3 times the cost of the flat strap. And a 30 foot 7/8” KERR is quite a big pile of rope. I didn’t confirm this with the Bubba people but I suspect the new Renegade addressed the space issue. By matching the rating to a typical 20 foot flat strap (20,000 lb. typical flat strap vs. 19,000 lb. Bubba rope) allows the use of 3/4“rope. So a 20 feet rope is actually manageable.I feel the 20 foot strap however is too short and 30’ would be better. If you need the extra energy, 20 feet does not give you enough room to build up momentum particular on slippery stuff or starting off uphill. I feel 30’ is the minimum. Again I will leave it up to the Bubba boys to tell me whether the ¾ inch diameter is up to the task at 30’ or if we need to move up to the next bigger diameter. I would like to see the 20 foot Bubba rope come in a larger bag. I have no intentions of spending the time to coil it up and put the Velcro strap on. I just want to shove it into the bag. I guess a compression type bag would be ideal for quickly tossing it in but still making it into a small package. But any bag is better than none when it comes to storing it in the vehicle. A bag is more manageable and more likely you will take your rope along for the ride.
TestPart of my testing involved giving my students a chance to see and feel the difference between a flat strap and a Bubba rope. In one class we had 5 JKU’s (4 doors) and 1 JK (2 doors). Each vehicle was stuck in a sand berm and pulled up and out by another student with the flat strap and then the Bubba rope. Each student experienced being the stuckee and being the driver of the recovery vehicle.The flat strap broke when the JK (2 door) tried to pull out a full size JKU (4 door). It is possible we over stressed the flat strap with the first 5 pulls. But I believe it was the necessary extra momentum the 2 door vehicle built up on his third attempt to pull out a much heavier vehicle and the strap exceeded its breaking strength. When we switched to the Bubba rope the smaller JK pulled out the larger JKU on the first try. In the debriefing all the students preferred the Bubba rope. They agreed the Bubba rope made for a smoother pull. I have gone through 2 flat straps and am on my third this year alone. That one broke and its replacement was frayed in another recovery involving a rock as an anchor. Once there is a fray or nick, retire the strap! It is not worth the risk to see if you can get by with it. As a rule it is not a good idea to incorporate a strap or kinetic energy recovery rope into the rigging for a winch extraction. The stretch built into them for a dynamic recovery, will preload the winch rigging and create even more recoil in the event of a line failure. We use the “dynamic” recovery method- using a strap or rope - most of the time because generally vehicles are “shallowly stuck” and it is quick. As a result, we don’t always take the time to ensure a few safety steps. Whether a flat strap or Bubba rope, I recommend that you take the time to put a blanket over the rope or strap and keep everyone back out of the danger zone. I hope that KERR as represented by the Bubba rope becomes the new standard for recovery when a winch is not called for. We will know that for sure when the “boulevard trucks” all have Bubba ropes as required accessories. |
|
|||
Related Articles from Badlands Off-road Adventures
|
||||
Did you miss the previous articles?
|
||||
Some Upcoming Events
You will notice we are kicking off our back to the desert season with a class in Borrego Springs on October 18th. This is a Friday and allows you to combine it with the OAUSA Borrego Fest weekend. Check their website for details. We will have monthly clinics in Borrego Springs until April next year. Our new stock of Winch Bandanas has arrived. We now have Red, Orange, Blue, Green, Gold, and Natural.
|
||||
Winch Clinic October 13, 2013
This one day clinic starts with the basics. If you are considering installing a powered winch on your vehicle, or have one already but need training to learn how to get the best from it and do it safely, you need to take this class. The one day course covers: safety related issues, basic operation of the winch, simple and complex riggings, stuck assessment, winch capability, and minimizing environmental impact. This is a hands on class. By the end of the day you will be safely rigging some complex recoveries. More Details... You can register directly at http://www.4x4training.com/calendar/calendar.php#Winch |
||||
Death Valley October 25-28, 2013
This is a 4 day trip on the back roads in Death Valley. We will drive the Panamint Mountains, drive past Badwater Basin (lowest spot in North America), visit Chloride Ghost town, Titus Canyon, check out Ubehebe Crater, Teakettle junction, The Race Track & Lippencott Mine Road, camp at the Warm Springs and leave via Steal Pass up to the high meadows, then take Dedeckera Canyon down to the Eureka Sand Dunes. All four days will see some light to moderate 4-wheeling. Much of the trip is quite remote with random or no cell service. Check out the details and sign up on the website: http://www.4x4training.com/Adventures/Deathvalley.html You can register directly at http://www.4x4training.com/calendar/calendar.php#Deathvalley |
||||
New Stock - More Colors - Winch Recovery Bandana
The Bandana layout follows the “Vehicle Recovery Plan” with pathways to more detail. A unique section of the Bandana, gives the steps for a “Winch Rigging Check: Walk through” so that you verify every element of the rigging before you commit to the pull. Stuff this in your recovery kit and you will always be ready! Pick up or order the Winching DVD too! There is no substitute for hands on training. If you can, sign up for one of Badlands Off-Road Adventure’s Winching Clinics. Warning – the Bandana and DVD are not a substitute for proper training and use of quality equipment that is used within the bounds of their safe working load. We advise you to use the information provided in both the Winching Recovery Bandana and the "Basic to Advanced Winching and Recovery DVD" at your own risk. We cannot control the quality and specifications of the equipment used and the methods actually employed. |
||||
|
Winch Recovery Bandana Order Button
Order a Basic to Advanced Winching & Recovery DVD too!
|
||||
|
|
| Back | | Phone 310-374-8047 |
